Product ID:BATTERY,DRY AND FLUID
MSDS Date:01/01/1987
FSC:6140
NIIN:01-214-0353
MSDS Number: BGQRR

CONCORDE BATTERY CORP

2009 SAN BERNARDINO RD
WEST COVINA, CA 91790-1006
US

Emergency Phone: 818-962-4006/714-989-8522AFTER HOUR

Info Phone: 818-813-1234

Cage: 63017

CONCORDE BATTERY CORP

WEST COVINA, CA 91790-1006 US

Telephone: 800-255-3924/818-813-1234

Cage: 63017

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

OSHA PEL 0.05 MG/M3;1910.1025

ACGIH TLV: 0.15 MG/M3;DUST 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LEAD OXIDE RED (PB3O4)

CAS: 1314-41-6

RTECS: OG5425000

OSHA PEL 0.05 MG/M3 AS PB

ACGIH TLV: 0.15 MG/M3 AS PB

SULFURIC ACID (SARA III)

CAS: 7664-93-9

RTECS: WS5600000

Fraction By Weight: 30 - 38%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

LD50 LC50 Mixture:TLV FOR SULFURIC ACID IS 1 MG/M3.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE-LEAD MAY CAUSE GI UPSET,LOSS OF
APPETITE,DIARRHEA,CONSTIPATION,CRAMPING,LACK OF SLEEP &
FATIGUE.CONTACT WITH SULFURIC ACID MAY LEAD TO EYE,SKIN &
RESPIRATORY TRACT IRRITATION,CORNEAL & LUNG DAMA GE.CHRONIC-LEAD
MAY CAUSE ANEMIA,KIDNEY& NERVOUS SYSTEM DAMAGE.ACID CAN CAUSE
BRONCHITIS,EROSION OF TOOTH ENAMEL.
Explanation of Carcinogenicity:CONTAINS LEAD AND LEAD OXIDE
Effects of Overexposure:LEAD MAY CAUSE GI UPSET, LOSS OF APPETITE,
DIARRHEA, CONSTIPATION, CRAMPING, LACK OF SLEEP & FATIGUE. CONTACT
WITH SULFURIC ACID MAY LEAD TO EYE, SKIN & RESPIRATORY TRACT
IRRITATION, CORNEAL & LUNG DA MAGE.
Medical Cond Aggravated by Exposure:THE PRODUCT IS A NON SPILLABLE
BATTERY.

First Aid:GET MEDICAL ATTENTION IMMEDIATELY.EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES.HOLD EYELIDS OPEN.INHALED:REMOVE
TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.ORAL:DO NOT INDUCE
VOMITING .IF CONSCIOUS,DRINK LARGE AMOUNT OF WATER/MILK.CALL A
PHYSICIAN IMMEDIATELY.NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point:NONE
Extinguishing Media:CO2, FOAM/DRY CHEMICAL. WATER SPRAY MAY BE USED TO
KEEP FIRE EXPOSED CONTAINERS COOL.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:NOT COMBUSTIBLE, BUT SUBSTANCE IS A
STRONG ACID. REACTS WITH MOST METALS RELEASING FLAMMABLE,
POTENTIALLY EXPLOSIVE HYDROGEN GAS.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. VENTILATE AREA.
COVER SPILL WITH SODIUM BICARBONATE OR SODA AND MIX. WASH ENTIRE
AFFECTED AREA WITH PLENTY OF WATER.
Neutralizing Agent:SODIUM BICARBONATE

Handling and Storage Precautions:STORAGE-STORE IN A COOL,DRY,VENTILATED
AREA WITH ACID RESISTANT FLOORS AND GOOD DRAINAGE.PROTECT FROM
PHYSICAL DAMAGE.
Other Precautions:ONLY HANDLE/STORE IN AREAS WHERE UNLIMITED WATER
SUPPLY IS AVAILABLE. DO NOT GET IN EYES, ON SKIN OR ON CLOTHING.
WASH THOROUGHLY AFTER HANDLING AND BEFORE EATING OR DRINKING.

Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF AIRBORNE CONCENTRATION EXCEEDS TLV, A
NIOSH-APPROVED MIST RESPIRATOR IS RECOMMENDED. IF CONCENTRATION
EXCEEDS CAPACITY OF RESPIRATOR, USE SELF-CONTAINED BREATHING
APPARATUS.
Ventilation:GOOD GENERAL VENTILATION IS SUFFICIENT FOR MOST CONDITIONS
(10 ROOM VOLUMES PER HOUR).
Protective Gloves:RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES/FACE SHIELD
Other Protective Equipment:RUBBER APRON, FACE SHIELD, EMERGENCY SHOWER
AND EYE BATH
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
UNDATED MSDS.

HCC:Z4
Boiling Pt:B.P. Text:275F,135C
Vapor Pres:3.8 - 18.7
Vapor Density:>1
Spec Gravity:1.220 - 1.285
pH:<1
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:100% (ELECTROLYTES)
Appearance and Odor:COLORLESS LIQUID IN BATTERY CASE W.LEAD PLATES.
Percent Volatiles by Volume:<100

Stability Indicator/Materials to Avoid:YES
ALL METALS AND ORGANIC PRODUCTS
Stability Condition to Avoid:DO NOT POUR WATE OVER ACID.
Hazardous Decomposition Products:SULFUR OXIDES AT HIGH TEMPERATURES,
REACT WITH CYANIDES TO FORM POISONOUS HYDROGEN CYANIDE AND HYDROGEN
SULFIDE.

Waste Disposal Methods:DISPOSE OF BATTERIES IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS FOR LEAD ACID BATTERIES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.